Knowledge

The reed is an independent action unit of the jacquard mechanism of the LCL tufting loom. Its action sequence determines the quality of the jacquard. According ...

It must be closed before point A, otherwise the yarn will enter the hook groove and form cut pile; in order to ensure that the loop forming process is accuratel...

Figure 9 shows the point diagram of the tufting needle and loop hook movement mechanism of the designed LCL tufting machine. The solid line in the figure is the...

The LCL jacquard component is composed of tufting needles, looping hooks, and cutters. The transmission mechanism of the tufting needles

The working mechanism of the LCL carpet tufting machine whether the yarn is looped or cut on the base fabric is similar to that of other types of cut pile carpe...

There are many types of carpet tufting looms, but they all have the same weaving principle. The carpet tufting machine uses the coordinated sequential movement ...

The reed timing determines the loop-forming effect in Level Cut Loop(LCL )tufting machine when loop pile. Acquired the loop-forming technological requirements b...

1. Check surface by eye: if the surface looks very fine, means good. If the surface looks coarse, not good.

101.Traffic: The passing back and forth of persons over a given carpet surface area 102.Tuft bind: The force required to pull out a tuft from a carpet surface

81.Seam: In carpet installation, the line formed by joining the edge of two pieces of carpet by various techniques – tape, hand sewing, etc.

61.Piece dyed: Carpet dyed by immersion in an aqueous dye bath

41.Indoor air quality: A term used to describe the quality of air breathed by the occupants of a building

21.Cut pile: A pile surface created by cutting the loops of yarns formed in a tufted or woven carpet 22.Cut and loop pile: A carpet in which the face is a comb...

1. Abrasion resistance: The ability of carpet pile fibres to resist dulling or wear through the abrasive action of foot traffic.

https://www.wxmatale.com/

Woven carpets do not require secondary backing. However, apply a thin latex coating on the back of the carpet, called back coating, to remove all creases and fo...

The amount of dead yarn produced by two carpets is the same as that of a steel wire loom carpet, so the yarn cost is low. The two fabrics are woven at the same ...

The patterns of these carpets come in two to five colors. They are usually made of cut wool, but they can also be made into a combination of cut wool and uncut ...

These are carpets of one color. Each row of fluff is formed on a metal wire and then recovered in the weaving sequence. If a knife is attached to the wire, it w...

Wilton weaving is a general method that can be used to create many different pile textures. Carpets manufactured in this way are particularly suitable for contr...